Product ID:INDUCOTE POLYURETHANE ENAMELS, 852300
MSDS Date:07/01/1990
FSC:8010
NIIN:00N091141
Status Code:A
MSDS Number: CJGZN

FINNAREN & HALEY INC

901 WASHINGTON ST
CONSHOHOCKEN, PA 19428
US

Emergency Phone: 215-825-1900

Info Phone: 215-825-1900; 215-825-1184 (FAX)

Cage: 9V982

FLECKS PAINT SPOT

TOMS RIVER, NJ 19428 US

Telephone: 1-610-825-1900

Cage: TO153

KEROSENE (PETROLEUM), HYDROTREATED; (MINERAL SPIRITS). VP

CAS: 64742-47-8

RTECS: OA5504000

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

ALKYD RESINS

CAS: 63148-69-6

RTECS: WZ6250000

POLYURETHANE RESIN

CHROME YELLOW; (LEAD CHROMATE)

CAS: 1344-37-2

RTECS: GE4599900

OSHA PEL 0.05 MG/M3

ACGIH TLV: 0.15 MG/M3

C.I. PIGMENT RED 224 (MFR'S CAS #2475-85-6)

CAS: 128-69-8

ACGIH TLV: 0.1 MG/M3

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES
Health Hazards Acute and Chronic:NOTE:LEAD APPEARS ON NAVY LIST OF
OCCUP CHEM REPRO HAZS. SEEK CONSULTATION FROM APPROP HLTH
PROFESSIONALS CONCERNING LATEST HAZ LIST INFO & SAFE HNDLG & EXPOS
INFO . INGEST:GI DISTRESS INCL NAUS , VOMIT & DIARR. ASPIR OF MATL
INTO LUNGS CAN CAUSE CHEM PNEUM WHICH CAN BE FATAL. INHAL:MAY CAUSE
NOSE & THROAT IRRIT. MAY CAUSE NERV SYS DEPRESS CHARACT BY
FOLLOWING PROGRESSIVE STEPS:HDCH, DIZZ, NA US, STAG GAIT, CONFUSN,
UNCON. REPORTS HAVE ASSOC RPTD & PRLNG OCCUP OVEREXP TO SOLV W/PERM
BRAIN & NERV SYS DMG. INTENTIONAL MISUSE BY DELIB CONCENTRATING &
INHALING CONTENTS MAY BE HARMFUL/FATAL. EY ES:MAY CAUSE SEVERE
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:LEAD CHROMATE:IARC MONOGRAPHS, VOL 49,
PG 49, 1990: GROUP 1. NTP 8TH ANNUAL REPORT ON CARCINOGENS, 1998:
KNOWN TO BE CARCINOGEN. HUMAN:LUNG.
Effects of Overexposure:HLTH HAZ:IRRITATION, REDNESS, TEARING, BLURRED
VISION. SKIN: PROLONGED OR REPEATED CONTACT CAN CAUSE MODERATE
IRRITATION, DEFATTING, DERMATITIS.

First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. TREAT
SYMPTOMATICALLY. CONSULT MD. EYES: FLUSH IMMEDIATELY WITH LARGE
AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. TAKE TO MD FOR MEDICAL
TREATMENT. SK IN: WASH AFFECTED AREAS WITH SOAP & WATER. REMOVE
CONTAMINATED CLOTHING. CONSULT MD IF IRRITATION PERSISTS.
INGESTION: DO NOT INDUCE VOMITING. CONSULT MD OR POISON CONTROL
CENTER IMMEDIATELY. TREAT SY MPTOMATICALLY.

Flash Point Method:TCC
Flash Point:=43.9C, 111.F
Lower Limits:1.0%
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:FLAMMABILITY CLASSIFICATION: OSHA: CLASS
II. DOT: COMBUSTIBLE.

Spill Release Procedures:REMOVE SOURCES OF IGNITION & PROVIDE
VENTILATION. LARGE SPILLS MAY BE SCOOPED UP WITH NONSPARKING TOOLS.
PROVIDE NIOSH APPROVED RESPIRATORY PROTECTION IF REQUIRED. SMALL
QUANTITIES MAY BE PICKED UP WI TH ABSORBENT MATERIAL. SEE DISPOSAL
PRECAUTIONS.

Handling and Storage Precautions:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. STORE AWAY FROM HIGH TEMPERATURES, SPARKS
& FLAMES. AVOID PROLONGED SKIN CONTACT. DO NOT BREATHE SPRAY MIST.
Other Precautions:GROUND CNTNRS WHILE POURING & LIM FREE FALL TO FEW
INCHES TO PVNT STATIC SPKS. AVOID SPONT COMBUST OF CONTAM RAGS &
OTHER EASILY IGNITABLE ORG ACCUMS (SUCH AS SPRAY BOOTH RESIDUES) BY
IMMED IMMERSION IN WATER. EMPTIED CNTNRS MAY RETAIN HAZ
PROPERTIES. DO NOT CUT, PUNCTURE/ WELD ON/NEAR CNTNR. STORE LG
QTYS (SUPP DATA)

Respiratory Protection:PROVIDE ADEQUATE VENTILATION. IF TLV OF PRODUCT
IS EXCEEDED, A NIOSH APPROVED SCBA WITH A FULL FACEPIECE OPERATED
IN PRESSURE DEMAND OR OTHER POSITIVE PRESSURE MODE IS ADVISED.
Ventilation:PROVIDE SUFFICIENT MECHANICAL AND/OR LOCAL EXHAUST
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV.
Protective Gloves:RESISTANT GLOVES SUCH AS BUNA-N (NITRILE RUBBER).
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA . TO PREVENT PROLONGED SKIN CONTACT, WEAR IMPERVIOUS
CLOTHING & BOOTS.
Supplemental Safety and Health
OTHER PREC:ONLY IN BUILDINGS DESIGNED TO COMPLY WITH OSHA 1910.106.

Boiling Pt:>165.6C, 330.F
B.P. Text:330-398F
Vapor Pres:SEE INGREDIENTS
Vapor Density:HVR/AIR
Spec Gravity:0.95-1.1
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:48.0 +/- 1.0

Stability Indicator/Materials to Avoid:YES
UNKNOWN.
Hazardous Decomposition Products:MAY PRODUCE NOXIOUS FUMES WHEN HEATED
TO DECOMPOSITION, AS IN WELDING. FUMES MAY CONTAIN CO, NITROGEN
OXIDES.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:PLACE IN CLOSED CONTAINERS. SEE OTHER
PRECAUTIONS. INCINERATE (FIRST OPEN CLOSED CONTAINERS) OR USE
SECURE LANDFILL I/A/W LOCAL, STATE & FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.